Carrier Fan Relay Wiring Diagram
Fuse box diagram (fuse layout), location and assignment of fuses and relays BMW 6-Series E63/E64 (2004-2010) 630i, 635d, 645Ci, 650i, and M6.
Checking and Replacing Fuses
The wiring circuits in the vehicle are protected from short circuits by fuses. This greatly reduces the chance of damage caused by electrical problems.
To check a fuse, look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse. Be sure to replace a bad fuse with a new one of the identical size and rating.
Fuses of the same amperage can be temporarily borrowed from another fuse location if a fuse goes out. Replace the fuse as soon as possible.
Note
- Before replacing a fuse check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
- When replacing a blown fuse, it is important to use only a fuse having the correct amperage rating. The use of a fuse with a rating other than indicated may result in a dangerous electrical system overload.
- If a properly rated fuse continues to blow, it indicates a problem in the circuit that must be corrected.
- Spare fuses and a pair of plastic tweezers are located in the compartment for the onboard tool kit (in the trunk under the floor mat).
- Information on fuse allocation is located below the bracket for the onboard tool kit, see below.
Warning!
Never attempt to repair a blown fuse, and do not replace a defective fuse with a substitute of another color or amperage rating, as this could lead to overloading of the wiring, ultimately resulting in a fire in the vehicle.
Fuses in the glove compartment
To access:
- Press the button on the back in the center of the partition (1) and pull out the partition upward (arrow 2).
- Press the coupling downward (arrow 3), and fold the lid (4) forward.
| № | A | Protected circuits |
|---|---|---|
| 1 | 50 | Dynamic stability control (DSC) |
| 2 | 60 | Petrol: Secondary air pump relay |
| Diesel: Fuel heater | ||
| 3 | 40 | Blower output stage |
| 4 | 40 | up to 09.2005: Active steering |
| 20 | as of 09.2005: Power-saving relay, electronic damper control | |
| 5 | 50 | Light module |
| 6 | 50 | Light module |
| 7 | 50 | Car access system |
| 30 | Ignition / starter electronic | |
| 8 | 60 | N62: |
| Integrated supply module (IVM) | ||
| N62 with SMG: | ||
| Fuse carrier, engine electronics (F01: Hydraulic pump relay, SMG) | ||
| S85: | ||
| B+ potential distributor | ||
| DME relay | ||
| Fuse carrier, engine electronics (F01) | ||
| N52: | ||
| B+ potential distributor | ||
| DME control unit | ||
| DME relay | ||
| Fuse carrier, engine electronics: | ||
| F05: Relay, fuel injectors | ||
| F07: VVT relay | ||
| F08: Hydraulic pump relay, SMG | ||
| F010: Engine breather heating relay | ||
| 9 | 60 | Electric fan |
| 10 | 30 | up to 09.2005: Driver's door module |
| as of 09.2005: Body-gateway module (LHD: window lift, driver's side; RHD: window lift, passenger's side) | ||
| 11 | 5 | Basic body module (central locking system, window lift, windscreen wiper relay) |
| 12 | 30 | up to 09.2005: Passenger's door module |
| as of 09.2005: Body-gateway module (LHD: window lift, passenger's side; RHD: window lift, driver's side) | ||
| 13 | 7.5 | up to 09.2005: Instrument cluster control unit |
| 30 | VTG transfer case; as of 09.2005: Control unit, transfer box | |
| 15 | S85; as of 09.2005: Sequential manual transmission (SMG) | |
| 14 | 30 | Seat module, front right (not semi-electric basic seat) |
| Switch, passenger's seat adjustment (RHD; semi-electric basic seat) | ||
| Passenger's lumbar support switch (RHD; semi-electric basic seat) | ||
| Switch, driver's seat adjustment (LHD; semi-electric basic seat) | ||
| Driver's lumbar support switch (LHD; semi-electric basic seat) | ||
| 15 | 5 | Car access system |
| 16 | 30 | Windscreen wiper relay |
| 17 | 15 | S85; up to 09.2005: Sequential manual transmission (SMG) |
| 5 | as of 09.2005: Steering column switch cluster | |
| 18 | 30 | up to 09.2005: Relay, headlight washer |
| as of 09.2005: Body-gateway module | ||
| 19 | 5 | USA: Gear indicator lighting |
| S85: EDC Electronic damper control | ||
| 20 | 20 | SHZH independent/auxiliary heater: Heater Independent auxiliary heater |
| EDC Damper Control: Power-saving relay, electronic damper control | ||
| 21 | 30 | Seat module, front right (not semi-electric basic seat) |
| Switch, driver's seat adjustment (RHD; semi-electric basic seat) | ||
| Driver's lumbar support switch (RHD; semi-electric basic seat) | ||
| Switch, passenger's seat adjustment (LHD; semi-electric basic seat) | ||
| Passenger's lumbar support switch (LHD; semi-electric basic seat) | ||
| 22 | 30 | Basic body module (LHD: window lift rear, driver's side; RHD: window lift rear, passenger's side) |
| 23 | 30 | S85; as of 09.2005: Relay, electric vacuum pump |
| 24 | 30 | Basic body module (LHD: window lift rear, passenger's side; RHD: window lift rear, driver's side) |
| 25 | 30 | Dynamic stability control (DSC) |
| 26 | 7.5 | IHKA Basic: Heating/air conditioning system |
| 20 | as of 09.2005: Power-saving relay, terminal 15 | |
| 27 | 30 | Basic body module (central locking system) |
| 28 | 20 | Steering column switch cluster |
| 29 | 10 | OBDII socket |
| Airbag | ||
| 30 | 15 | IHKA High: Heating/air conditioning system |
| 20 | Fuel pump output stage | |
| Fuel pump relay | ||
| 31 | 30 | LHD: Seat module, front left (heated, active backrest-width adjustment, active seat) |
| RHD: Seat module, front right (heated, active backrest-width adjustment, active seat) | ||
| 32 | 10 | up to 09.2005: Dynamic drive |
| S85; up to 09.2005: Relay, electric vacuum pump | ||
| as of 09.2005: | ||
| Switch block, driver's door | ||
| Electrochromic outside mirror, driver's side | ||
| Electrochromic outside mirror, passenger's side | ||
| 33 | 30 | Centre console switch centre |
| LHD: Seat module, front right (heated, active backrest-width adjustment, active seat) | ||
| RHD: Seat module, front left (heated, active backrest-width adjustment, active seat) | ||
| 34 | 30 | up to 09.2005: CCC/M-ASK |
| 20 | as of 09.2005: CCC/M-ASK | |
| 35 | 5 | Navigation system |
| 36 | 7.5 | Comfort access control unit |
| Outer door handle electronic module, driver's side | ||
| Outer door handle electronic module, passenger's side | ||
| Electronic outer door handle module, rear left | ||
| Electronic outer door handle module, rear right | ||
| 37 | 10 | up to 09.2005: |
| TCU (telematics control unit) | ||
| ULF (universal charging & hands-free unit) | ||
| Eject box | ||
| 5 | 09.2005-03.2007: | |
| TCU (telematics control unit) | ||
| ULF (universal charging & hands-free unit) | ||
| Eject box | ||
| as of 03.2007: | ||
| ULF-SBX interface box | ||
| TCU (telematics control unit) | ||
| ULF-SBX-H interface box High | ||
| USB hub | ||
| Eject box | ||
| 38 | 10 | up to 09.2005: CD changer |
| 5 | as of 09.2005: CD changer | |
| 39 | - | Not used |
| 40 | 10 | DVD changer |
| 41 | 5 | as of 09.2005: Instrument cluster control unit |
| 42 | 15 | S85: Sequential manual transmission (SMG) |
| 43 | - | Not used |
| 44 | - | Not used |
| 45 | - | Not used |
| 46 | - | Not used |
| K6 | Relay, headlight washer | |
| K93 | Relay, electronic damper control (as of 09.2005) | |
| K96 | Fuel pump relay (M54 or N62) | |
| K9 | Power-saving relay, terminal 15 (as of 09.2005) | |
Fuses in the luggage compartment
Fold up the cover under the floor mat and remove the bracket for the onboard tool kit. Information on fuse allocation (1) and additional fuses (2) are provided there.
| № | A | Protected circuits |
|---|---|---|
| 50 | 20 | M54, N62: Fuel pump relay |
| N52, diesel: Fuel pump control (EKPS) | ||
| S85: Fuel pump output stage | ||
| 30 | as of 09.2005: Headlight washer pump | |
| 51 | 5 | Siren and tilt alarm sensor |
| Electrochromic interior rear view mirror | ||
| Microwave sensor, driver's door | ||
| Microwave sensor, passenger's door | ||
| Microwave sensor, rear left | ||
| Microwave sensor, rear right | ||
| 52 | 10 | Micro-power module |
| 40 | E64: | |
| Relay, convertible top 1 | ||
| Relay, convertible top 2 | ||
| 53 | 7.5 | up to 09.2005: Automatic soft-close drive, boot lid/tailgate |
| 09.2004-09.2005: | ||
| Comfort access control unit | ||
| Outer door handle electronic module, driver's side | ||
| Outer door handle electronic module, passenger's side | ||
| Electronic outer door handle module, rear left | ||
| Electronic outer door handle module, rear right | ||
| 30 | as of 09.2005: | |
| Active backrest width adjustment, passenger | ||
| Active backrest width adjustment, driver | ||
| 54 | 20 | up to 09.2005: Power-saving relay, terminal 15 |
| 40 | as of 09.2005: Rear window defogger | |
| 55 | 5 | up to 09.2005: Rain/headlight sensor |
| 40 | as of 09.2005: Boot lid lift | |
| 56 | 5 | as of 09.2005: Rain/headlight sensor |
| 57 | 20 | up to 09.2005: Micro-power module |
| 5 | IHKA Basic; as of 09.2005: Heating/air conditioning system | |
| 58 | 40 | up to 09.2005: Rear window defogger |
| 20 | as of 09.2005: Rear wiper relay | |
| 59 | 5 | Aerial tuner with remote control receiver |
| 60 | 5 | as of 09.2005: Rollover protection controller |
| 61 | 20 | up to 09.2005: |
| Front cigar lighter | ||
| Charging socket, glovebox | ||
| 7.5 | as of 09.2005: Cooler box | |
| 62 | 5 | up to 09.2005: Power-saving relay, terminal 15 |
| 30 | as of 09.2005: | |
| E64: | ||
| Relay for lowering rear window | ||
| Relay for raising rear window | ||
| 63 | 5 | up to 09.2005: |
| Electrochromic interior rear view mirror | ||
| Park distance control (PDC) | ||
| 20 | as of 09.2005: Independent auxiliary heater | |
| 64 | 10 | up to 09.2005: |
| Rear compartment display | ||
| Central information display | ||
| Controller | ||
| 15 | IHKA High; as of 09.2005: Heating/air conditioning system | |
| 65 | 10 | up to 09.2005: |
| Headset connection module | ||
| Head-up display | ||
| 66 | 5 | up to 09.2005: |
| Dynamic stability control (DSC) | ||
| VTG Transfer case: | ||
| Dynamic stability control (DSC) | ||
| Control unit, transfer box | ||
| 20 | E63: Panorama glass roof | |
| E64: Convertible top module | ||
| 67 | 10 | up to 03.2006: |
| Video module | ||
| Satellite receiver | ||
| 20 | as of 03.2006: | |
| Automatic soft-close drive, passenger's door (LHD) | ||
| Automatic soft-close drive, driver's door (RHD) | ||
| Automatic soft-close drive, rear right | ||
| 68 | 5 | up to 03.2006: |
| Centre console switch centre | ||
| Switch, driver's seat adjustment | ||
| Switch, passenger's seat adjustment | ||
| 20 | as of 03.2006: | |
| Automatic soft-close drive, driver's door (LHD) | ||
| Automatic soft-close drive, passenger's door (RHD) | ||
| Automatic soft-close drive, rear left | ||
| 69 | 5 | Park distance control (PDC) |
| 70 | 5 | up to 09.2005: Adaptive headlight |
| 10 | 09.2005-03.2007: Active cruise control | |
| as of 03.2007: | ||
| Active cruise control | ||
| Far-range sensor | ||
| Close-range sensor, right | ||
| Close-range sensor, left | ||
| 71 | 20 | up to 09.2005: |
| S85: Fuel pump output stage | ||
| 30 | as of 09.2005: Centre console switch centre | |
| 72 | 40 | up to 09.2005: |
| E64: | ||
| Relay, convertible top 1 | ||
| Relay, convertible top 2 | ||
| 20 | N62: Fuel pump relay | |
| Diesel: Fuel pump control (EKPS) | ||
| 73 | 30 | up to 09.2005: |
| E63: | ||
| Relay for lowering rear window | ||
| Relay for raising rear window | ||
| Trailer module | ||
| 09.2005-03.2007: | ||
| Hifi amplifier | ||
| 40 | as of 03.2007: Hifi amplifier | |
| 74 | 20 | up to 09.2005: Trailer socket |
| 10 | as of 09.2005: | |
| Centre console switch centre | ||
| Switch, driver's seat adjustment | ||
| Switch, passenger's seat adjustment | ||
| 75 | 30 | up to 09.2005: Control unit, trans- fer box |
| 10 | as of 09.2005: | |
| Satellite receiver | ||
| Digital tuner | ||
| Video module | ||
| 76 | 40 | up to 09.2005: Boot lid lift |
| 10 | as of 09.2005: Dynamic drive | |
| 77 | 5 | up to 09.2005: Aerial tuner with remote control receive |
| 10 | as of 09.2005: | |
| Head-up display | ||
| Headset connection module | ||
| 78 | 5 | as of 09.2005: |
| Dynamic stability control (DSC) | ||
| Control unit, transfer box | ||
| 79 | 7.5 | up to 09.2005: Electronic ride height control |
| 10 | as of 09.2005: | |
| Central information display | ||
| Controller | ||
| 80 | 30 | up to 09.2005: HiFi amplifier |
| 10 | as of 09.2005: | |
| Selector lever | ||
| Gear indicator lighting | ||
| Eject box | ||
| TCU (telematics control unit) | ||
| Compensator (mobile phone) | ||
| Fan, spare wheel well | ||
| Electronic night vision module | ||
| 81 | 7.5 | as of 09.2005: Electronic ride height control |
| 82 | 20 | up to 09.2005: |
| Luggage compartment socket outlet | ||
| Rear cigarette lighter | ||
| Socket outlet, rear | ||
| 7.5 | as of 09.2005: Tyre pressure control (RDC) | |
| 83 | 20 | up to 09.2005: |
| E63: Panorama glass roof | ||
| E64: Convertible top module | ||
| 30 | as of 09.2005: | |
| Active backrest width adjustment, driver (LHD) | ||
| Active backrest width adjustment, passenger (RHD) | ||
| 84 | 10 | up to 09.2005: Active cruise control |
| 15 | as of 09.2005: | |
| Transmission control | ||
| Sequential manual transmission (SMG) | ||
| 85 | 7.5 | as of 09.2005: Sequential manual transmission (SMG) |
| 86 | 15 | up to 09.2005: |
| Transmission control | ||
| Sequential manual transmission (SMG) | ||
| 40 | as of 09.2005: Active steering | |
| 87 | 20 | as of 09.2005: |
| Front cigar lighter | ||
| Charging socket, glovebox | ||
| 88 | 30 | up to 09.2005: Centre console switch centre |
| 20 | as of 09.2005: | |
| Luggage compartment socket outlet | ||
| Rear cigarette lighter | ||
| Socket outlet, rear | ||
| 89 | 10 | up to 09.2005: |
| Fan, MMC | ||
| Gear indicator lighting | ||
| Selector lever | ||
| Gear indicator lighting | ||
| Fan, spare wheel well | ||
| TCU (telematics control unit) | ||
| ULF (universal charging & hands-free unit) | ||
| Eject box | ||
| 5 | as of 09.2005: | |
| Electrochromic interior rear view mirror | ||
| Power-saving relay, terminal 15 | ||
| 90 | 200 | Fuse holder, front (fuse 1-33) |
| 91 | 100 | Diesel: DDE main relay |
| N62, TU: | ||
| Integrated supply module (IVM) | ||
| VVT relay 1 | ||
| VVT relay 2 | ||
| Variable valve timing gear control unit | ||
| 92 | 100 | Electric auxiliary heater |
| | ||
| I01061 | Rear deffogger | |
| I01068 | Terminal 30G | |
| I01069 | Terminal 15 | |
This website uses cookies to improve your experience. We'll assume you're ok with this, but you can opt-out if you wish. Cookie settingsACCEPT
Posted by: walterdrempaneso.blogspot.com
Source: https://fusecheck.com/bmw/bmw-6-series-e63-e64-2004-2010-fuse-diagram
Posting Komentar untuk "Carrier Fan Relay Wiring Diagram"